UNII:862GFQ832E

EMERGENCY OVERVIEW
Causes burns.Corrosive.
Potential Health Effects
Eye:
Causes eye burns.
Skin:
Causes skin burns.
Ingestion:
May cause severe and permanent damage to the digestive tract. Causes gastrointestinal tract burns.
Inhalation:
Causes chemical burns to the respiratory tract.
Chronic:
No information found.

---

Section 4 - FIRST AID MEASURES
Eyes: Immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately. Do NOT allow victim to rub eyes or keep eyes closed.
Extensive irrigation with water is required (at least 30 minutes).
Skin:
Get medical aid immediately. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Wash clothing before reuse. Destroy contaminated shoes.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:

---

Section 5 - FIRE FIGHTING MEASURES
General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Water may be ineffective. Material is lighter than water and a fire may be spread by the use of water. Vapors may be heavier than air. They can spread along the ground and collect in low or confined areas.
Extinguishing Media:
In case of fire, use water, dry chemical, chemical foam, or alcohol-resistant foam.

---

Section 6 - ACCIDENTAL RELEASE MEASURES
General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Clean up spills immediately, observing precautions in the Protective Equipment section. Provide ventilation.

---

Section 7 - HANDLING and STORAGE
Handling:
Keep container tightly closed. Do not get on skin or in eyes. Do not ingest or inhale. Use with adequate ventilation. Discard contaminated shoes.
Storage:
Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. Corrosives area.

---

Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls:
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate ventilation to keep airborne concentrations low.
Exposure Limits CAS# 5510-99-6: Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use.

---

Section 9 - PHYSICAL AND CHEMICAL PROPERTIES

Physical State: Liquid
Color: Amber Liquid
Odor: None reported.
pH: Not available.
Vapor Pressure: < 0.1 mm Hg @ 20 C
Viscosity: Not available.
Boiling Point: 255.0 - 260.0 deg C @ 760.00m
Freezing/Melting Point: -42 deg C
Autoignition Temperature: Not available.
Flash Point: 127 deg C ( 260.60 deg F)
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature:
Solubility in water:
Specific Gravity/Density: .9180g/cm3
Molecular Formula: C14H22O
Molecular Weight: 206.33

---

Section 10 - STABILITY AND REACTIVITY
Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
Incompatible materials, strong oxidants.
Incompatibilities with Other Materials:
Strong oxidizing agents.
Hazardous Decomposition Products:
Carbon monoxide, carbon dioxide.
Hazardous Polymerization: Has not been reported.

---

Section 11 - TOXICOLOGICAL INFORMATION
RTECS#:
CAS# 5510-99-6: SK8225000 LD50/LC50:
CAS# 5510-99-6: Draize test, rabbit, eye: 50 ug/24H Severe; Draize test, rabbit, skin: 2 mg/24H Severe.
Intravenous, rabbit: LDLo = 10 Carcinogenicity:
Di-sec-butylphenol, tech. (predom. 2,6-isomer) - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.

---

Section 12 - ECOLOGICAL INFORMATION

---

Section 13 - DISPOSAL CONSIDERATIONS
Dispose of in a manner consistent with federal, state, and local regulations.

---

Section 14 - TRANSPORT INFORMATION

IATA
Shipping Name: ALKYLPHENOLS, LIQUID, N.O.S.
Hazard Class: 8
UN Number: 3145
Packing Group: III
IMO
Shipping Name: ALKYLPHENOLS, LIQUID, N.O.S.
Hazard Class: 8
UN Number: 3145
Packing Group: III
RID/ADR
Shipping Name: ALKYLPHENOLS, LIQUID, N.O.S.
Hazard Class: 8
UN Number: 3145
Packing group: III

---

Section 15 - REGULATORY INFORMATION

European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: C
Risk Phrases:
R 34 Causes burns.
Safety Phrases:
S 24/25 Avoid contact with skin and eyes.
WGK (Water Danger/Protection)
CAS# 5510-99-6: No information available.
Canada
CAS# 5510-99-6 is listed on Canada's NDSL List.
CAS# 5510-99-6 is not listed on Canada's Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 5510-99-6 is listed on the TSCA inventory.

---

SECTION 16 - ADDITIONAL INFORMATION
N/A

DATA ITEMS CITED :

5

MOLECULAR FORMULA :

C14-H22-O

MOLECULAR WEIGHT :

206.36

WISWESSER LINE NOTATION :

2Y1&R BQ CY2&1

HEALTH HAZARD DATA

ACUTE TOXICITY DATA

TYPE OF TEST :

Standard Draize test

ROUTE OF EXPOSURE :

Administration onto the skin

SPECIES OBSERVED :

Rodent - rabbit

REFERENCE :

85JCAE "Prehled Prumyslove Toxikologie; Organicke Latky," Marhold, J., Prague, Czechoslovakia, Avicenum, 1986 Volume(issue)/page/year: -,228,1986

TYPE OF TEST :

Standard Draize test

ROUTE OF EXPOSURE :

Administration into the eye

SPECIES OBSERVED :

Rodent - rabbit

REFERENCE :

85JCAE "Prehled Prumyslove Toxikologie; Organicke Latky," Marhold, J., Prague, Czechoslovakia, Avicenum, 1986 Volume(issue)/page/year: -,228,1986 ** ACUTE TOXICITY DATA **

TYPE OF TEST :

LD50 - Lethal dose, 50 percent kill

ROUTE OF EXPOSURE :

Intravenous

SPECIES OBSERVED :

Rodent - mouse

DOSE/DURATION :

60 mg/kg

TOXIC EFFECTS :

Behavioral - sleep Behavioral - altered sleep time (including change in righting reflex) Behavioral - analgesia

REFERENCE :

JMCMAR Journal of Medicinal Chemistry. (American Chemical Soc., Distribution Office Dept. 223, POB POB 57136, West End Stn., Washington, DC 20037) V.6- 1963- Volume(issue)/page/year: 23,1350,1980

TYPE OF TEST :

LDLo - Lowest published lethal dose

ROUTE OF EXPOSURE :

Intravenous

SPECIES OBSERVED :

Rodent - rabbit

DOSE/DURATION :

10 mg/kg

TOXIC EFFECTS :

Behavioral - general anesthetic Behavioral - sleep

REFERENCE :

JMCMAR Journal of Medicinal Chemistry. (American Chemical Soc., Distribution Office Dept. 223, POB POB 57136, West End Stn., Washington, DC 20037) V.6- 1963- Volume(issue)/page/year: 23,1350,1980