Influence of the composition of monoacyl phosphatidylcholine based microemulsions on the dermal delivery of flufenamic acid.

Rita Kusriastuti, Asik Surya

Index: Int. J. Pharm. 475(1-2) , 156-62, (2014)

Full Text: HTML

Abstract

Although microemulsions are one of the most promising dermal carrier systems, their clinical use is limited due to their skin irritation potential. Therefore, microemulsions based on naturally derived monoacyl phosphatidylcholine (MAPL) were developed. The influence of the water, oil and surfactant content on dermal delivery of flufenamic acid was systematically investigated for the first time. A water-rich microemulsion led to significantly higher in vitro skin penetration of flufenamic acid compared to other microemulsions. The superiority of the water-rich microemulsion over a marketed flufenamic acid containing formulation was additionally confirmed. Differences in drug delivery could be explained by alterations of the microemulsions after application. Evaporation of isopropanol led to crystal-like structures of MAPL on the skin surface from the surfactant- or oleic acid-rich microemulsions. In contrast, the formation of this additional barrier was hindered in case of the water-rich microemulsion. The skin penetration of MAPL was additionally analyzed by combined ATR-FTIR and tape stripping experiments, where MAPL itself penetrated only into the initial layers of the stratum corneum, independent of the microemulsion composition. Since a surfactant must penetrate the skin to cause irritation, MAPL can be presumed as a skin-friendly emulsifier with the ability to stabilize pharmaceutically acceptable microemulsions. Copyright © 2014 Elsevier B.V. All rights reserved.